dd13 qbuantity control valve-----Shanghai Katalor Enterprises Co., Ltd.
   

0086-21-61182423

[email protected]

dd13 qbuantity control valve

  • Thickness: 6mm-80mm
  • Width: 1500mm-4200mm
  • Length: 3000mm-18000mm
  • Steel Standard: API 5L PSL1,API 5L PSL2
  • Heat Treatment: TMCP/Normalized/QT/DQ-T
  • Main Grades: X42,X46,X52,X56,X60,X65,X70,X80
(※ Click this button to inquiry)
■ Overview
[PDF]

11 14-13 1 11 14-13 - Freightliner Trucks

Connect electrical connector for quantity control valve. 5. For DD13 engines only, install the air compressor inlet coolant line fitting on to the side of the cylinder block.

What is the procedure to replace the quantity control valve…

Feb 17, 2015· ok, thats not the quanity control valve. it may be the 2 way valve on the fuel pump. if you remove the manifold which has the hoses from the fuel filter module to the high pressure pump, there is a valve that unscrews and usually sticks open allowing loss of prime.User rating: 5/5[PDF]

1009-10.PDF - Removal and Installation of Quantity …

REMOVAL OF QUANTITY CONTROL VALVE Remove as follows: 1. Steam clean engine and housing on high pressure fuel pump. 2. Drain fuel filter module by removing one of the fuel filters or by using the water in fuel drain.

Fuel Quantity Control Valve (FQCV) - Autoditex

The quantity control valve (also referred to as an inlet metering valve or flow regulator) is designed to control the quantity of diesel fuel flowing from the low pressure or lift …

2011 DD13 fuel quantity control valve. | TruckersReport ...

thetruckersreport› …› Trucks [ Eighteen Wheelers ]Apr 23, 2018· Just wanted to know if I install a new one if it has to be calibrated in the computer or not? I have the lopey idle thing goin on. Thanks, Rob.[PDF]

307-11.PDF - SPN 1077/FMI 6: Quantity Control Valve …

2 SPN 1077/FMI 6 - EPA07 This diagnostic is typically quantity control valve (QCV) current too high. Check as follows: 1. Disconnect the QCV. NOTE: It is necessary to zero the ohmmeter prior to measurement being taken. If the meter does not have an auto-

I have a question on a dd13. I have a DD13 with a no start ...

Hello Roy I have a question on a dd13. I have a DD13 with a no start issue. My commanded fuel pressure is at 310 bar and the measured is at 20 bar. It is not setting off a code. KW/NW is true. Fuel system is primed. I took the line off the pressure limiting valve while cranking and there is no fuel coming from there. I do see a pid where it is showing a quantity control valve commanded and ...ok, good, then low pressure pump is good. it needs a high pressure fuel pump. get the pump, lines. Roynot sure, I believe it is low preesure pump output yes, 7-10 bar 1 bar equals 15 lbs quantity control valve comes with the new pump. the spec of 10-12 ma is on the buttonhigh pressure fuel lines from the pump to the common rail. once you loosen them they are junkthank youit is part of the high pressure pump. when you get the pump, it will be the high pressure, low pressure and quantity control valve as an assembly Roythat is correctgood evening my name is ***** ***** I will assist was any codes set??? on the quantity control valve, was that desired or actual??? Royok, on the ma side. there is a desired and actual reading for the quantity control valve current draw. what is the low pressure fuel pressure reading??? Roydo you have the service link program from freightliner???ok, valve is working. can you get to the screen for low pressure fuel pump and tell me how many bar it is putting out??? also, have you pulled the filters and checked for being clogged?? especially the small one??? Roy

164/1 QUANTITY CONTROL VALVE LOW SIDE DRIVER …

Refer to section “Removal of the Quantity Control Valve – Two-Filter System” . Disconnect the 120-pin MCM connector. Inspect the harness connector for signs of damage: bent, spread, broken, corroded or unseated (push out) pins and sign of moisture in the connector or wire damage near the connector.

Detroit DD13, DD15, DD16 Fuel System Workshop Manual …

Detroit DD13, DD15, DD16 Fuel System Workshop Manual PDF. Format: PDF file Pages: 271 ... DDC-SVC-MAN-0082. Description: This manual provides instruction for repair the fuel system (2 and 3 filter) in Detroit DD13, DD15, DD16 EPA07/10/GHG14 engines. Topics List: Fuel System Overview ... Bypass and Quantity Control Valves Removal of the High ...[PDF]

307-11.PDF - SPN 1077/FMI 6: Quantity Control Valve …

2 SPN 1077/FMI 6 - EPA07 This diagnostic is typically quantity control valve (QCV) current too high. Check as follows: 1. Disconnect the QCV. NOTE: It is necessary to zero the ohmmeter prior to measurement being taken. If the meter does not have an auto-

I have a question on a dd13. I have a DD13 with a no start ...

Hello Roy I have a question on a dd13. I have a DD13 with a no start issue. My commanded fuel pressure is at 310 bar and the measured is at 20 bar. ... I do see a pid where it is showing a quantity control valve commanded and measured, while cranking I get 0 commanded and 10-12 mA measured.

164/1 QUANTITY CONTROL VALVE LOW SIDE DRIVER …

Refer to section “Removal of the Quantity Control Valve – Two-Filter System” . Disconnect the 120-pin MCM connector. Inspect the harness connector for signs of damage: bent, spread, broken, corroded or unseated (push out) pins and sign of moisture in the connector or wire damage near the connector.

9999 DETROIT DIESEL DD13 Recalls (4)

Detroit diesel: removal and installation of quantity control valve. air compressor coolant line removal is added to this procedure. no model or model years listed.

Detroit DD13, DD15, DD16 Fuel System Workshop Manual …

Detroit DD13, DD15, DD16 Fuel System Workshop Manual PDF. Format: PDF file Pages: 271 ... Bypass and Quantity Control Valves Removal of the High Pressure Fuel Pump ... Installation of the DD13 High Pressure Fuel Rail Feed Lines

Detroit DD15 Rough Idle with no fixes yet. | Page 2 ...

thetruckersreport› …› Trucks [ Eighteen Wheelers ]Oct 03, 2018· The valve he replaced is the high pressure fuel pump quantity control valve.. They are known for sticking and causing a surge.. the way to tell would be to open detroit diesel diagnostic link. you would open FSIC routing and compare control valve amperage as far as desired and actual they should be smooth and and not changing much at idle.. if ...

DD 13 15 Fuel System | Fuel Injection | Valve - Scribd

The quantity control valve has the following tasks: • • Regulation of the fuel feed to the high pressure fuel pump (5) Regulation of the rail pressure The MCM actuates the coil (3) of the quantity control valve (2) using a pulse width modulated signal.

DD13 Code Book 2013 | Turbocharger | Fuel Injection

DD13 Code book. Save . DD13 Code Book 2013. For Later. save. ... Cylinder #3 Needle Control Valve. Abnormal Operation (MAX) Injector Cylinder #3 Needle Control Valve. Current too Low Quantity Control Valve. Abnormal Operation (MAX) Injector Cylinder #4 Needle Control Valve. ... Documents Similar To DD13 Code Book 2013. DDC-SVC-BRO-0115_2014r1 ...

Detroit Diesel DD13, DD15, DD16 GHG17 Engine Workshop ...

Topics in the Detroit Diesel DD13, DD15, DD16 GHG17 Engine Workshop Manual: ... Resetting Quantity Control Valve Adaptive Values – Two-Filter System 9.22 Two Stage Valve ... You're viewing: Detroit Diesel DD13, DD15, DD16 GHG17 Engine Workshop Manual $ 149.95.[PDF]

The Aftertreatment System Technician's Guide (DDC …

The Aftertreatment System Technician's Guide (DDC-SVC-MAN-0036) was revised to include the DD15 engine. MANUAL REFERENCE ... 25 Needle Control Valve Common (cyl 1,2,3) - pin 3 26 Needle Control Valve (cyl 1) - pin4 27 NC 28 NC 29 DOC Outlet Temp Sensor Table 6 …[PDF]

1 8 09-13 - DDCSN

Quantity Control Valve - Three-Filter System 8 09-13 ... 3 Installation of the Quantity Control Valve - Three-Filter System Install as follows: 1. Lubricate the O-ring seal on the new quantity control valve with clean diesel fuel. ... Removal and Installation of the Quality Control Valve - Three-Filter System Keywords: DD13, DD15, DD16, OEM ...

Service Information Bulletins 2010 - DDCSN

2010 Service Information Bulletins for EPA07/10 DD Platform Fuel Manual DDC-SVC-MAN-0082. Section 1 Fuel System Overview. Ref # ... Removal and Installation of Quantity Control Valve. This is a new section, with procedures to remove and install the high pressure fuel flange. DD13. Section 19 High Pressure Fuel Rail Feed Lines. Ref # Subject ...

Detroit DD15 EPA07 Fuel System Troubleshooting Manual …

Detroit DD15 EPA07 Fuel System Troubleshooting Manual PDF. Format: PDF download Pages: 292 ... 3.7 Quality Control Valve 3.8 Fuel Rail 3.9 Fuel Injectors 4.0 Symptom Based Diagnostics – Hard Starting ... 6.3 Resetting the Pressure Limiting Valve Counter 6.4 Resetting Quantity Control Valve Adaptive Values 6.5 Fuel System Priming SPN Code ...

Clarke Power Services | Detroit Diesel - DD15 Engine ...

The Detroit Diesel DD15 Engine Diagnostics class goes for 3 days and is designed to give students a review of the DD15 engine sub systems along with real world failure modes and analysis.
Inquiry >>
[email protected]0086-21-61182423
Your name :
Your tel :
* Your mail :
Your company :
Your country :
* Inquiry :